Enerzone EUROSTAR Spezifikationen

45546A Printed in Canada 29-06-2012 INSTALLATION AND OPERATION MANUAL EUROSTAR Safety tested according to ULC S627, UL1482 and ASTM E1509 by Intert

10 Eurostar Installation and Operation Manual 2.2 Regulations Covering Pellet Stove Installation When installed and operated as described in these i

Eurostar Installation and Operation Manual 11 3 CLEARANCES TO COMBUSTIBLE MATERIAL The clearances shown in this section have been determined by test

12 Eurostar Installation and Operation Manual 3.3 Back Wall Installation For a back wall installation, in order to allow the LCD sliding support to

Eurostar Installation and Operation Manual 13 3.6 Floor Protection For floor protection clearances refer to the following table: FLOOR PROTECTION LE

14 Eurostar Installation and Operation Manual 4 VENTING SYSTEM 4.1 General Even though the chimney draft is mechanical, a suitable venting system wil

Eurostar Installation and Operation Manual 15 Here is an example to help you calculate Equivalent Vent Length. On the following figure the EVL can be

16 Eurostar Installation and Operation Manual 4.4.1 Permitted Termination Location Canada: Letter Min. clearances Description A 12’’ (30 cm)

Eurostar Installation and Operation Manual 17 United States:  Not Less than 36’’ (91 cm) above any forced air inlet located within 120’’ feet (305

18 Eurostar Installation and Operation Manual 4.5.2 Through Wall Installation (Main Floor or Basement) 1. Position stove following clearances give

Eurostar Installation and Operation Manual 19 4.5.3 Through Roof Installation 1. Position stove following clearances given in Section 3.2 Minimum

2 Eurostar Installation and Operation Manual THANK YOU FOR CHOOSING THIS ENERZONE PELLET STOVE As one of North America’s largest and most respected p

20 Eurostar Installation and Operation Manual 4.5.4 Through a Prefabricated Chimney The best method to make an installation through a prefabricated

Eurostar Installation and Operation Manual 21 4.5.5 Through an Existing Masonery Fireplace 1. Position stove, following clearances shown in Sectio

22 Eurostar Installation and Operation Manual 4.5.6 Through an Existing Masonery Chimney 1. Position stove following clearances shown in Section 3

Eurostar Installation and Operation Manual 23 PART B - OPERATION 5 GENERAL INFORMATION 5.1 Operation Warnings, Cautions and Recommendations  KEEP

24 Eurostar Installation and Operation Manual  NEVER TRY TO REPAIR OR REPLACE ANY PART OF THE STOVE UNLESS INSTRUCTIONS ARE GIVEN BY THE MANUFACTUR

Eurostar Installation and Operation Manual 25  THIS STOVE IS DESIGNED TO PROVIDE THE OPTIMUM PROPORTIONS OF FUEL AND AIR TO THE FIRE IN ORDER TO BU

26 Eurostar Installation and Operation Manual Your success with zone heating will depend on several factors: Proper stove size, stove location, heati

Eurostar Installation and Operation Manual 27 6 STOVE CONTROLS 6.1 General Information The stove uses a LCD touch screen, the latest technology in co

28 Eurostar Installation and Operation Manual Description of each main status page icon: Indicates that the stove is in the manual mode. It will th

Eurostar Installation and Operation Manual 29 6.1.2 Configuration and Operation Diagram 6.1.3 Selecting the Language From the main status page, cho

Eurostar Installation and Operation Manual 3 Table of Contents 1 INTRODUCTION...

30 Eurostar Installation and Operation Manual 6.1.6 Adjusting the Combustion Level (Heat Output) The stove’s input range goes from 8,500 BTU to 50,

Eurostar Installation and Operation Manual 31 6.1.6.2 FUEL Q. ADJUST (Fuel Quality Adjustment) The “FUEL QUALITY ADJUSTMENT” will allow you to modi

32 Eurostar Installation and Operation Manual If overheating occurs, fan speed reduction will be automatically deactivated and an envelope icon will

Eurostar Installation and Operation Manual 33 6.1.9 Selecting the Pilot Cycle Note: This icon will be visible on the Main Status Page only on thermo

34 Eurostar Installation and Operation Manual 6.1.10 Filling or Purging Auger Housing Note: This function is disabled when the stove is running. To f

Eurostar Installation and Operation Manual 35 7 STOVE OPERATION 7.1 First Startup Before starting your stove, make sure that the burn pot, the baffle

36 Eurostar Installation and Operation Manual 7.5 Shutting Down Procedure To turn your stove off, press the “ON/OFF” icon on the Main Status Page. T

Eurostar Installation and Operation Manual 37 8 MAINTENANCE 8.1 Stove Maintenance 8.1.1 Recommended Maintenance Schedule Use this as a guide under a

38 Eurostar Installation and Operation Manual 8.1.2 Cleaning the Baffle, the Heat Exchangers and the Combustion Chamber Remove and clean the three p

Eurostar Installation and Operation Manual 39 1. Clean the burn pot using the scraper provided with the stove or a brush. 2. Release the clips on

4 Eurostar Installation and Operation Manual 6.1.8 Selecting Manual or Thermostat Mode...

40 Eurostar Installation and Operation Manual 4. Verify that the clean out trap gasket is still in good condition, replace it if needed. 8.1.4 Ash

Eurostar Installation and Operation Manual 41 8.1.5 Cleaning the Air Wash System Vacuum the ashes that may have accumulated in the airwash system in

42 Eurostar Installation and Operation Manual WARNING: IF YOU HAVE TO CHANGE THE DOOR GLASS, MAKE SURE YOU INSTALL THE NEW GASKETS AT THE SAME PLACE

Eurostar Installation and Operation Manual 43 Clean and vacuum any dirt or ash build-up in the exhaust channels and exhaust blower housing being ca

44 Eurostar Installation and Operation Manual 8.2 Venting System Maintenance CAUTION: REGULARLY EXAMINE THE VENTING SYSTEM, THE JOINTS, AND THE SEAL

Eurostar Installation and Operation Manual 45 9 TROUBLESHOOTING When you have issues with your stove, your first reaction may be to call technical su

46 Eurostar Installation and Operation Manual WARNING: RISK OF ELECTRICAL SHOCK. IF YOU NEED TO MANUALLY TEST, MANIPULATE OR REPLACE ANY COMPONENTS,

Eurostar Installation and Operation Manual 47 in the menu. Page 4 and 5 will allow you to test every electrical component. Note that you will be able

48 Eurostar Installation and Operation Manual  Pressure tap (located on the exhaust blower) is blocked. Pull off the air hose from the exhaust blo

Eurostar Installation and Operation Manual 49  The stove ran out of pellets. Refill the hopper. Press “Reset” then “Feed and Start”.  The burn

Eurostar Installation and Operation Manual 5 1 INTRODUCTION 1.1 About Pellet Heating Pellet stoves offer a dramatic improvement in the convenience o

50 Eurostar Installation and Operation Manual  Inadequate fuel is used. Remove the burn pot, make sure that all openings are clear and check tha

Eurostar Installation and Operation Manual 51  The auger is jammed or auger motor failed. Go to the troubleshooting page (see Section 9.2 Testing

52 Eurostar Installation and Operation Manual  The flue is not properly installed. Make sure the venting system meets the criteria in the installat

Eurostar Installation and Operation Manual 53  Power was interrupted while burning. After the cool down cycle, the stove will restart using the la

54 Eurostar Installation and Operation Manual 10 WIRING DIAGRAM

Eurostar Installation and Operation Manual 55 11 FUSES ACCESS WARNING: UNPLUG THE STOVE BEFORE CHANGING THE FUSES. All fuses are located inside the

56 Eurostar Installation and Operation Manual 12 COMPONENT LOCATION

Eurostar Installation and Operation Manual 57 13 EXPLODED VIEW AND REPLACEMENT PARTS

58 Eurostar Installation and Operation Manual IMPORTANT: THIS IS DATED INFORMATION. When requesting service or replacement parts for your stove, plea

Eurostar Installation and Operation Manual 59 # Item Description Qty 35 44144 EXHAUST FAN 1 36 21382 OUTLET EXHAUST BLOWER GASKET 2 37 PL64

6 Eurostar Installation and Operation Manual 1.2 Eurostar Specifications Fuel Type Wood pellets, Wood and Hay pellets, Bark pellets and Switch Grass

60 Eurostar Installation and Operation Manual # Item Description Qty 75 PL64259 BOTTOM REAR PANEL 1 76 60036 THERMOSTAT TERMINAL 1 77 60196

Eurostar Installation and Operation Manual 61 APPENDIX A: HORIZONTAL AND VERTICAL VENT CHART Possible Vertical vent length (feet) Possible Horiz

62 Eurostar Installation and Operation Manual Instead, if the installation consisted of a horizontal vent coming out at the back of the stove on a to

Eurostar Installation and Operation Manual 63 APPENDIX B: LCD SLIDING BRACKET MOUNTING Step 1 The LCD sliding bracket is preassembled on the right h

64 Eurostar Installation and Operation Manual Step 3 Take the Telco black wire (D) which is located on the rear bottom panel and plug it into the bac

Eurostar Installation and Operation Manual 65 APPENDIX C: FLAME CARACTERISTICS Efficient flame An efficient flame should be bright but not too vigor

66 Eurostar Installation and Operation Manual Fire with not enough air If the flame pattern is tall, lazy and orange with black smoky tips it is gene

Eurostar Installation and Operation Manual 67 APPENDIX D: INSTALLING A THERMOSTAT Using a thermostat will help you maintain a constant temperature

68 Eurostar Installation and Operation Manual Here is an example of what your thermostat could look like: Connect one wire on “RH” and the other wir

Eurostar Installation and Operation Manual 69 APPENDIX E: MOBILE HOME INSTALLATION Anchor the stove WARNING: FOR MOBILE HOME INSTALLATION, IT IS MAN

Eurostar Installation and Operation Manual 7 1.3 Overall Exterior Dimensions A: FRESH AIR INTAKE B: EXHAUST

70 Eurostar Installation and Operation Manual APPENDIX F: COMBUSTION AIR SUPPLY WARNING: FOR MOBILE HOME INSTALLATION, IT IS MANDATORY TO CONNECT THE

Eurostar Installation and Operation Manual 71 Also make sure that the fresh air intake backdraft shutter (A) works freely. The fresh air intake back

72 Eurostar Installation and Operation Manual ENERZONE LIMITED LIFETIME WARRANTY The warranty of the manufacturer extends only to the original consum

8 Eurostar Installation and Operation Manual PART A – INSTALLATION 2 INSTALLATION SAFETY INFORMATION 2.1 Installation Warnings, Cautions and Recomm

Eurostar Installation and Operation Manual 9  DO NOT CONNECT TO OR USE IN CONJUNCTION WITH ANY AIR DISTRIBUTION DUCTWORK.  THE VENTING SYSTEM MUS